0.42404 w endobj It features H3 classification and is suitable for general machine shop fabricating, assembly, storage, and warehousing. 750 Ibs. 70). 1 0 0 1 0 0 cm 577.04 4.54 l <>stream After hanging the hoist make sure that the hook latch closes. Tools Needed. 2A). <>stream (Fig 6. /Xi16 11 Tf Do not use the limit switch for routine stops during normal operation. (For more information contact: Sievert Crane and Hoist, \(708\) 771-1600, parts@sievertelectric.com, www.sievertcrane.com)Tj Check for loose nuts, bolts, and s c r e w s. c. nspect for worn, corroded, cracked, or distorted parts. /Xi9 11 Tf But if the hoist ever fails to lift the rated load while the motor is turning, the overload limit safety clutch must be re-adjusted. 0 G Failure to follow the safety rules and other. endstream BT Q q ift10/15/20 ft. P 2/3P Power upply115v, 1 phase, 60 z Full load amp draw10a Duty cycle15 min./hr. 103-0045 REV. 0 G 0 g 0 G q endobj Installation, Operation. 0 G Check hooks for deformities, cracks, or chemical damage. 0.42404 w 6), lower hook block (Ref. 1 0 0 1 0 0 cm 0.42404 w q Q 0 g t is controlled with the pendant control box. (For more information contact: Sievert Crane and Hoist, \(708\) 771-1600, parts@sievertelectric.com, www.sievertcrane.com)Tj c. nspect for worn, corroded, cracked, or distorted parts including pins, bearings, shafts, keys, and gears. Q Weve got everything to make your business go like Air Chain Hoist, 1000 lb. Dayton lectric Chain oists, Models covered in this manual, are warranted by Dayton lectric Mfg. 0 G Any Deficiency Causing mproper Operation O K R e q u i r e d Operating Controls * * * imit witches * * * Any deficiency causing improper operation Brake Mechanism * * * 1. lippage or excessive drift 2. lazing, contamination or excessive wear o o k s xcessive throat opening 15% bent or twisted more than 10 degrees, damaged hook latch, wear, chemical damage, worn hook bearing C h a i n * * * nadequate lubrication. 64 0 obj Replace hooks showing any of these signs. 36 0 obj Place chain container bracket flush against the suspension frame. 0.42404 w 34.96 4.54 m q 1 0 0 1 0 0 cm Run load hook down to its lowest position. S 0.42404 w 5, 6 Dayton Operating nstructions and Parts Manual Dayton lectric Chain oists 2XY32, 2XY33,2TD6 thru 2TD9 Maintenance (Continued) Control Block B l k O r g B l u r n W h t Y e l Y e l B l u B l u W h t U 1 W h t V2 B l k B l k U 2 V 1 B l k R e c t i f i e r r y B l u R e l a y W h t M o t o r W h t B r a k e B r n B l k Terminal Connection 115V AC 60z Pendant Control Box Figure 5 Wiring Diagram 6, 7 Dayton Operating nstructions and Parts Manual Models 2XY32 2XY33 2TD6 thru 2TD9 M a i n t e n a n c e PCTO COTUD OVROAD MT CUTC The overload limit safety clutch has been set to within 1.3 to 1.8 times the rated load of the hoist. q An important phase of hoist maintenance is chain 4, 5 Dayton Operating nstructions and Parts Manual Models 2XY32 2XY33 2TD6 thru 2TD9 M a i n t e n a n c e PCTO COTUD inspection. Q of grease. [] 0 d Electric Wire Rope Hoist, 1,000 lb, 90 ft, Hook Mounted - No Trolley and Electric Wire Rope Hoist, 500 lb, 10 ft, Hook Mounted - No Trolley are just a couple of the items we sell. crew & ut 21. 1 0 0 RG Hanging the Fan. 10. (For more information contact: Sievert Crane and Hoist, \(708\) 771-1600, parts@sievertelectric.com, www.sievertcrane.com)Tj q 3) should be r e p l a c e d. c. nspect hook once daily for cracking, extreme wear or spreading. 1 0 0 1 340.96 5.98 Tm Co. iles, llinois U..A. 0)fk#Cksmv]XP76uXowy+KE`YYo)tF;^\VZOU|:xeme? 6bDOF"6=qXon1pS_41Tf!4pbxj*8 _?Se3o6M;1--2V&4l5|6Z{u#zQ!n1f1:* YO& !8y(vI[oDynFu,ut|LX^cLE}`V>SW\kK9]_l#"M"*V^). 35 0 obj Refit springs (Ref. Q Q BT [] 0 d 1. 0 J BT f it does not, repeat step 5 and 6 until the hoist operates with the rated load only, but not with 1.3 to 1.8 times rated l o a d. 8. Find Electric Chain Hoist, 500 lb, 10 ft, Hook Mounted - No Trolley, 115V and Electric Chain Hoist, 1,000 lb, 15 ft, Hook Mounted - No Trolley, Red when you shop our huge assortment. 54 0 obj Brake not holding 2. 1 0 0 rg 3. ), GARDNER-DENVER TECHNICAL MANUAL CPTEN-136 07/03 Hoist Inspection and Maintenance Guide Inspection Record For: Hoist Model. endstream Wheeling, IL (800) 323 7366. endstream BT JavaScript must be enabled in order for you to use this site. 0 G a. The light weight 3.7 lbs. 1 0 0 rg Q 1 0 0 rg 40 0 obj 3-Phase Simplex Page 8-13. cbperformance.com Please read this entire brochure prior to installing your CB Performance Products MAGNASPARK II distributor. 577.04 4.54 l 1 0 0 1 0 0 cm <>stream Before installing, please read the following important information 1. 1 w 34.96 4.54 m 1 0 0 1 34.96 5.98 Tm Serial Number Date Purchased Table of Contents Page Safety Messages2 Guidelines for Product Use2 Operation, You can read the recommendations in the user guide, the technical guide or the installation guide for BH FITNESS T1 BASIC. /Xi20 11 Tf 34.96 4.54 m 1 0 0 1 0 0 cm Manufactured for Dayton lectric Mfg. <>stream <>stream TABLE OF CONTENTS. BT ET 577.04 4.54 l endobj ome inspections should be made frequently (daily to monthly) and others periodically (monthly to yearly). <> 0 g endobj /Xi1 11 Tf 0.42404 w 0 g Between Hooks 12 51/64 in, Pull to Lift Rated Load 31 lb, Lever Length 12 13/64 in, Brake Double Disc Brake, Weston Style, Reeving 1, Chain Alloy Steel - G80, Chain Length 15 21/32 ft, Finish Handwheel, Hooks, Housing, Lever, Side Plates: Powder Coating; Chain Guides: Zinc Plated, Standards ANSI/ASME B30.21, EN13157, Includes Safety Latch Hooks, Hoist Overload Protection No, Manual Chain Hoist, Load Capacity 2, 000 lb, Hoist Lift 10 ft, Hook Opening 1 7/64 in, Min. 1 0 0 1 0 0 cm 1 0 0 1 34.96 5.98 Tm or Hoist, Electric, 440/880 lb., 1.1 HP, 120V, 440/880 lb., 38 ft., 120v? 6 0 obj 1 0 0 1 34.96 5.98 Tm f power disconnect point is out of sight, lock it in the open position and tag to prevent any unexpected application of power. ET Q 1. [] 0 d S Capacity and Mini Cable Hoist, 0.1 ton, Red. q 0 g M a i n t e n a n c e P C T O nspection procedures are listed under three general classifications based upon intervals at which inspection should be performed daily, quarterly, and annually. endstream 19 0 obj endobj 32 0 obj 0.42404 w endobj Sign In to access your account information. (For more information contact: Sievert Crane and Hoist, \(708\) 771-1600, parts@sievertelectric.com, www.sievertcrane.com)Tj S 55 0 obj <>stream a. et unworn chain hang vertically with a light load (about 20 pounds) on it to remove slack. [] 0 d Check overall wear by selecting an unused length of chain and comparing it to a used length. LEVER OPERATED CHAIN HOISTS Operating, Maintenance & Parts Manual SERIES 602/603 Manually Lever Operated Chain Hoist Maximum Capacity: Series 602: 550 Pounds (250 Kg.) q Make certain that all persons are warned of an approaching load and that all persons remain clear of a suspended load. ET GETTING STARTED 5 - Section 2.01: Tools You Will Need 5 - Section, 15GAL STEEL OIL DRAIN WITH 110V PUMP OWNER S MANUAL WARNING: Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. <>stream Q Improper, Paper shredder 20-2HS 80C POWERSHRED OPERATING INSTRUCTIONS NOTICE D'UTILISATION MANUAL DEL PROPIETARIO BETRIEBSANLEITUNG 20 80 20C 80C 20-2HS Edition 0/0.70.999.0 Edition 0/0 20-2HS 80C Paper shredder, Machine Model Serial# Register product online @ www.mathey.com PO Box 472110 Tulsa, OK 74147 USA Toll Free: 800-725-7311 918-447-1288 office 918-447-0188 fax www.mathey.com MSA, ARCO Electric Products Installation and Maintenance Manual Low Voltage Automatic Power Factor Correction Capacitor Systems 2013 READ CAREFULLY These instructions are intended to cover good practices in, Electric Meat Grinder OWNER S MANUAL WARNING: Read carefully and understand all INSTRUCTIONS before operating. <>stream 1000 Ibs. Q o. ET 1. endstream <>stream Wipe chain clean with a cloth periodically and apply a coat of 90 weight gear oil. [] 0 d endobj Between Hooks 13 25/64 in, Housing Length 5 5/8 in, Housing Width 5 5/8 in, Housing Depth 5 3/64 in, Pull to Lift Rated Load 67 lb, Brake Double Disc Brake, Weston Style, Standards ANSI/ASME B30.16, EN13157, Includes Safety Latch Hooks, Hoist Overload Protection No, Hoist Mount Hook Mounted - No Trolley, Manual Chain Hoist, Load Capacity 1, 000 lb, Hoist Lift 20 ft, Hook Opening 3/4 in, Min. endstream 0.42404 w /Xi11 11 Tf 1 0 0 RG 27 0 obj <>stream 0.42404 w ELECTRIC HOIST 93251 ASSEMBLY AND OPERATING INSTRUCTIONS Jib Boom not included. 1 w WARNING! When moving a load be certain that the pathway is free of any o b s t r u c t i o n s. 16. 2 0 obj 1 w Privacy Policy --more-- All operators should familiarize themselves with the appropriate controls prior to any, INSTRUCTION MANUAL NFC Communication Tray Model: HHX-IT3-Z ENGLISH CONTENTS Introduction3 Important safety information4 Know your unit6 Transferring data to the PC7 Care and maintenance8, INSTRUCTION MANUAL 758 Heavy-duty Ratchet Guy Wire Cutter Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. <>stream While Dayton attempts to assure that its products comply with such codes, it cannot guarantee compliance, and cannot be responsible for how the product is installed or used. DC2) Part No. 6. Q 0 J Keep brake surface and lining free BRAK CCK PROCDUR 1. 0 g This will permit chain to pile freely and eliminate possibility of jamming which may occur if chain is placed in container by hand. BT Failure to follow the safety rules and other basic safety, WHEEL MANUAL CONGRATULATIONS! 0 g endobj endstream 1 w 1 w Avoid jogging the controls or making quick reversals when lifting or lowering a load. 577.04 4.54 l Do not use in areas that contain explosive dust, gases, or vapors. q Q 2953AT Winch, AWWA Butterfly Valve Operation and Maintenance Manual Series 511A & 510A 20 and Smaller, READ CAREFULLY - FAILURE TO FOLLOW INSTRUCTIONS AND SAFETY RULES MAY RESULT IN SERIOUS INJURY, Andersen Electric Window Opener for Andersen Awning and Roof Windows, UHIR Series. 34.96 4.54 m 0 J Cable Hoist. Operating Manual. 0 g Form No. ET S BT Be sure the load chain is not twisted as it travels into the hoist housing. q 0 J Check for burned relay. MODEL TCR 10 Ton and 25 Ton Capacity. BT 577.04 4.54 l YOU are responsible for the safe operation of this equipment. d. Check for open, bent or damaged hook latches. KEEP IN VEHICLE! 1 0 obj 1 0 0 RG q 2. Need a Electric Cable Hoist, 440-880 lb. 1 0 0 rg ET Q 3491 Mission Oaks Blvd., Camarillo, CA 93011 Visit our website at: http://www.harborfreight.com, Owner s Manual Gantry Cranes Fixed Height Gantry Crane MODEL NUMBER: SERIAL NUMBER: CAPACITY IN TONS: Telescoping Gantry Crane Bushman AvonTec 262-790-4200, 800338-7810, Fax 262-790-4200 www.bushmanavontec.com, Mini-led spotlight with magnetic base Model 95799 Assembly And Operation Instructions Due to continuing improvements, actual product may differ slightly from the product described herein.